Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
  
1
 Wiping cloths: clean, use restricted
22
  
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
  
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
 
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
  
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
X
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
X
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
X
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
X
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
  
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   QUAT 200-400 ppm                   Dishwasher Temperature   120-140 °F or label
Food Temperatures:   BLUE CHEESE 40, TUNA 35, ROAST BEEF 170, CHICKEN GRAVY 197, BROWN GRAVY 194, GREEN BEANS 199, CHILI 188, MASHED POTATOES 37, ROAST BEEF 37, RAW HAMBURGER 40, CHICKEN 33, MUSHROOMS 31, CORN BEEF 29, MILK 40
 
General Comments
 
Report and Instructions Received By   CHRIS M. TEMINIS /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/05/2013 Time In  1:15 PM Time Out  2:35 PM Sanitation Score  83 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*12  Observed the following improper handwashing practices. Employees only washing hands for 10-15 seconds. Employees shall wash their hands for 20-30 seconds. Provide for hands to be properly washed as often as necessary to keep them clean and free of contamination Immediate/Onsite
*41  Observed the following toxic chemical container(s) to not be properly labeled: There was no label on sanitizer located by mixer. Provide for all chemical containers that no longer have the original label on them to be labeled with chemical content. Employee will label sanitizer. 750.820 Immediate/Onsite
8  Observed the following food products to be improperly stored. 1. There is a box's of ketchup on floor in dry storage area. 2. Box's of food on floor under shelf in the walk-in freezer. 3. No lid on flour in dry storage area. Provide for all food products to be stored at least six inches off of the floor. 750.130 Next Inspection
9  Observed food service employees to be handling ready-to-eat foods without minimizing direct hand contact with the food product. Cup found in fish batter & in flour in dry storage area. Food employees shall avoid direct contact with ready-to-eat food whenever possible and, to the extent possible, shall handle ready-to-eat food only with suitable utensils such as a deli tissue, spatulas, tongs, or single-use gloves. Next Inspection
10  Observed the following utensil(s) to be improperly stored. Handle found in almonds in dry storage area. Provide for all utensils to be stored in one of the following manners: 1) Clean and dry 2) In the food product with the handle up and out of the food product 3) In a dipper well, using potable water 4) Malt collars and frozen dessert utensils either clean and dry or ina dipper well. 750.280 Next Inspection
23  Observed the following contact surfaces to be unclean. Gaskets have debris in them located on main prep cooler & Fish reach-in cooler. Clean and maintain. 750.800 Next Inspection
36  Observed the following floor areas to be unclean: Floor in walk-in cooler has debris on it. Provide for all flooring areas to be in a clean condition. 750.1220 Next Inspection
     
     
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   CHRIS M. TEMINIS /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/05/2013 Time In  1:15 PM Time Out  2:35 PM Sanitation Score  83 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   BB160  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  CULVER'S OF BOURBONNAIS Address  983 N CONVENT ST
Owner or Operator   MAIER, BOBBY City   BOURBONNAIS Zip Code   60914
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
     
Report and Instructions Received By   CHRIS M. TEMINIS /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  03/05/2013 Time In  1:15 PM Time Out  2:35 PM Sanitation Score  83 (100 Minus Demerits)
By  Steven Lamb (Sanitarian) Adjusted Score  93